CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Osborn 76205

TM2907 Layout Fluid Remover

Revision Date: 2/8/02

Osborn International, 5401 Hamilton Ave., Cleveland, OH 44114 (330) 467-4195

108-88-3 40-50 50 skin NA 200 NA ppm

110-19-0 20-30 150 NE 150 NE ppm

67-63-0 10-20 400 500 400 NE ppm

67-64-1 10-20 750 1000 1000 NE ppm

74-98-6 1-10 1000 Asphyxiant 1000 Asphyxiant ppm

Acceptable ceiling concentration for toluene - - 300 ppm; max peak above ceiling - - 8 hr shift - - 500 ppm.

May cause dizziness or narcosis in high vapor concentrations. Will cause defatting of skin. Effects are reversible. Long term exposure (years) to high concentrations of vapor may cause lung, liver or kidney damage. The solvents listed have been reported to affect the central nervous system. Aspiration hazard if swallowed. Eye and skin irritant. May irritate respiratory tract. Deliberately concentrating and inhaling the vapor of the contents may be harmful or fatal.

May cause cardiac abnormalities. Overexposure to toluene may cause nasal and brain damage.

NA

Give oxygen. Do not induce vomiting. Wash eyes and skin with water for 15 minutes. Get medical help. Never administer adrenalin following overexposure.

Ingestion, Inhalation, Skin

Inhalation - Difficulty in breathing. Skin - redness. Ingestion - vomiting.

Heart Disease, Respiratory Disorders

Boiling Point -40F to 246F

Vapor Pressure at 70F 26

VAPOR DENSITY (AIR=1) 4.0

EVAP. RATE(BUTYL ACETATE=1) >1

SPECIFIC GRAVITY (WATER=1) The ratio of the weight of a volume of material to the weight of an equal volume of water. Usually expressed as greater than one (>1). 0.8

Solubility Nil

Appearance Clear

Odor Solvent

PH: Not Applicable

STABILITY: STABLE

INCOMPATIBILITY:- strong oxidizers, acids, chlorine, acetaldehyde, ethylene oxide, isocyanates, aluminum surfaces above 120F.

HAZARDOUS THERMAL DECOMPOSITION/COMBUSTION PRODUCTS:- Carbon dioxide.

HAZARDOUS POLYMERIZATION: WILL NOT OCCUR

WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm.

Ozone Depleting Substances:

None

FLAMMABILITY 4 , REACTIVITY 0 , HEALTH 1

NFPA:

FLAMMABILITY 4 , REACTIVITY 0 , HEALTH 2

SARA 313 TITLE III - TOXIC CHEMICALS LIST:

Toluene (CAS 108-88-3)

DOT Shipping Name:

Consumer Commodity, ORM-D

Use NIOSH approved respirator if TLV limit is exceeded.

Local exhaust - yes

None required if spraying.

Safety glasses.

Long Sleeves and Long pants

Do not smoke while using. Wash hands after use.

Flash Point -142F TCC

LOWER EXPLOSION LIMIT : 1.8

UPPER EXPLOSION LIMIT : 9.5

EXTINGUISHING MEDIA:- Water fog, carbon dioxide, foam, dry chemical

UNUSUAL FIRE AND EXPLOSION HAZARDS:- Heated cans may burst.

SPECIAL FIRE FIGHTING PROCEDURES Keep containers cool. Use equipment or shielding required to protect against bursting or venting containers.

SPILL PROCEDURES:_ Use absorbent sweeping compound to soak up material. Put into container. Dispose as hazardous waste.

WASTE DISPOSAL METHODS:_ Dispose as hazardous waste in accordance with EPA RCRA.

PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: This section contains precautions for general handling and storage of this particular material. This section is generally for SPBD customers; although the statements should generally apply for internal use as well. Any in-plant rules or procedures should take priority over these handling and storage precautions. Keep away from heat, sparks, or open flame. Store at temperatures below 120F.

OTHER INFORMATION: When spraying more than one half can continuously or more than one can consecutively, use NIOSH approved respirator.

3