MATERIAL SAFETY DATA SHEET

(Complies with OSHA Communication Standard 29CFR 1910.1200 Dept. of Labor.)

CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Osborn 76380 (New Can)

BP714 LV Black RTV

Revision Date: 2/8/02

MANUFACTURER/SUPPLIER'S/NAME:

Osborn International, 5401 Hamilton Ave., Cleveland, OH 44114 (330) 467-4195

COMPOSITION/INFORMATION ON INGREDIENTS

PRODUCT COMPOSITION/ ACGIH TLV OSHA PEL

CAS REG NO. WGT. % TWA STEL TWA STEL UNITS

Polydimethylsiloxane

63148-62-9 50-60 NE

Crystalline Silica

14808-60-7 30-40 NE

Amorphous Silica

7631-86-9 1-10 NE

Methyl Tris Silane

22984-54-9 1-10 NE

Dihydroxypolydimethylsiloxane

63148-60-7 1-10 NE

Additional Component Information:

Outer compartment contains a flammable hydrocarbon propellant (Propane/Isobutane/n-Butane blend).

HAZARDS IDENTIFICATION

HEALTH HAZARD DATA (ACUTE AND CHRONIC)

No injury from silica dust should occur during reasonable use. If use creates respirable particles, some respiratory systems injury may occur. This product, as with any chemical, may enhance allergic conditionsin certain people. No known chronic health effects, but unnecessary exposure to any chemical should be avoided. Cured sealant is nonhazardous.

OTHER:

Crystalline Silica as respirble dust is listed as a potential carcinogen by IARC and NTP. In the case of this product, it has been incorporated into the sealant and wetted by the binder resin, no longer presenting a dust hazard. therefore, the supplier of the RTV material is not indicating crystalline silica as a carcinogen or hazardous ingredient.

CARCINOGENICITY:

NA

FIRST AID

Give oxygen. Do not induce vomiting. Wash eyes and skin with water for 15 minutes. Get medical help.

ROUTES OF ENTRY

Ingestion, Inhalation, Skin

SIGNS AND SYMPTOMS OF OVEREXPOSURE_

Eye and skin irritation. Irritation of mucous membrane and intestinal tract.

MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:_

None known

PHYSICAL AND CHEMICAL PROPERTIES

Boiling Point ND

Vapor Pressure at 70F 60

VAPOR DENSITY (AIR=1) >1

EVAP. RATE(BUTYL ACETATE=1) <1

SPECIFIC GRAVITY (WATER=1) The ratio of the weight of a volume of material to the weight of an equal volume of water. Usually expressed as greater than one (>1). 1.3

Solubility Nil

Appearance Black Paste

Odor Slight

PH: Not Applicable

STABILITY AND REACTIVITY

STABILITY: STABLE

INCOMPATIBILITY:- Water causes curing.

HAZARDOUS THERMAL DECOMPOSITION/COMBUSTION PRODUCTS:- Carbon dioxide. Methylethylketoxime (2-butanone oxime) Silicon dioxide.

HAZARDOUS POLYMERIZATION: WILL NOT OCCUR

REGULATORY INFORMATION

CALIFORNIA PROPOSITION 65:

NONE

Ozone Depleting Substances:

None

HMIS:

FLAMMABILITY 1 , REACTIVITY 1 , HEALTH 1

NFPA:

FLAMMABILITY 1 , REACTIVITY 1 , HEALTH 1

SARA 313 TITLE III - TOXIC CHEMICALS LIST:

None

DOT Shipping Name:

Consumer Commodity, ORM-D

CONTROL MEASURES

Respiratory Protection Equipment

Use NIOSH approved respirator if TLV limit is exceeded.

VENTILATION:

Local exhaust - yes

PROTECTIVE GLOVES:

Butyl rubber.

EYE AND FACE PROTECTION:

Safety glasses.

OTHER PROTECTIVE EQUIPMENT:

Long Sleeves and Long pants

SAFE HANDLING

Do not smoke while using. Wash hands after use.

PRECAUTIONS FOR SAFE HANDLING AND USE

Flash Point 250F T O C

LOWER EXPLOSION LIMIT : ND

UPPER EXPLOSION LIMIT : ND

EXTINGUISHING MEDIA:- Water fog, carbon dioxide, foam, dry chemical

UNUSUAL FIRE AND EXPLOSION HAZARDS:- Heated cans may burst.

SPECIAL FIRE FIGHTING PROCEDURES Keep containers cool. Use equipment or shielding required to protect against bursting or venting containers.

SPILL PROCEDURES:_ Remove product and contain for salvage disposal.

WASTE DISPOSAL METHODS:_ Dispose in accordance with Federal, State and Local regulations.

PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: This section contains precautions for general handling and storage of this particular material. This section is generally for SPBD customers; although the statements should generally apply for internal use as well. Any in-plant rules or procedures should take priority over these handling and storage precautions. Keep away from heat, sparks, or open flame. Store at temperatures below 120F.

OTHER INFORMATION: When spraying more than one half can continuously or more than one can consecutively, use NIOSH approved respirator.

NFPA 30B Level:

1